Contact Us

If you have any questions, you can contact us. Required fields are marked *

introduction to partial replacement of coarse aggregate by granite waste

Partial Replacement of Coarse Aggregate with Broken Ceramic Tiles in

Will ceramic waste replace coarse aggregate?

Learn More

Project csac - SlideShare

Aug 06, 2014 · 12 COCONUT SHELL AGGREGATE CONCRETE To find the optimum replacement of coconut shell 13. GCE Kannur 13 MIX DESIGN Mass of cement (in kg/m3) 383 Mass of water (in kg/m3) 191.6 Mass of fine aggregate (in kg/m3) 626.36 Mass of coarse aggregate (in kg/m3) 1200.8 Mix ratio 1: 1.635: 3.135 14.

Learn More

Characteristic Studies on Concrete by Partial Replacement of

These are going to affect the fertility of soil. In present study the detailed characteristic studies of concrete is carried out by partial replacement of natural sand by waste granite powder in concrete composition with different percentages (0%, 10%, 20%, 30%, 40%, 50%).The mechanical properties of concrete like compressive strength, tensile strength are carried out by replacing the quantity of sand with waste granite powder with different percentages as mentioned above.

Learn More

Experimental study on strength characteristics on M25

coarse aggregates, rather than the properties of the coarse aggregates itself. Usually an aggregate with specific gravity more than 2.55 and absorption less than 1.5% (except for light weight aggregates) can be regarded as being of good quality. Where aggregates strength is higher, concrete strength is also higher. 2.5 Coconut shell

Learn More

A STUDY ON PROPERTIES OF CONCRETE WITH CERAMIC WASTE

Natural fine Aggregate (%) 75 50 75 Ceramic Waste (%) 25 50 25 Table 3 Mix proportions for various percentages of fine aggregates Materials W/c Cement Fine Aggregate Coarse aggregate Mix Proportion for control mix Ratio 0.5 1 1.34 2.83 Kg/m 3 186 414 552 1173 Mix design for 25% replacement of ceramic waste Ratio 0.5 1 1.38 2.83

Learn More

PAPER OPEN ACCESS Mechanical properties of concrete with

Coarse aggregate, crushed granite of 20 mm maximum size was clean and then dried in an oven at 1050C for a duration of 24 hours to remove its moisture content [9]. This is also to ensure that the amount of water required are consistent throughout the study. The dry coarse aggregate was well graded with the passing percentage lies within the range

Learn More

An Experimental Study on Properties of Concrete using

Concrete is the most widely used construction material in the world it is a mixture of cement, sand, coarse aggregate and water. Storage and safe disposal of i

Learn More

Effect of Substitution of Crushed Waste Glass as Partial

Reusing of waste glass in concrete production is among the attractive option of achieving waste reduction and preserving the natural resources from further depletion thereby protecting the environment and achieving sustainability. This present study examines the possible reuse of waste glass crushed into fine and coarse aggregate sizes as partial substitute for natural fine and coarse

Learn More

PDF Replacement of Coarse Aggregate by Demolished Brick Waste

1) To determine the suitability of brick waste as replacement of coarse aggregate in concrete production. 2) To investigate the mechanical and physical properties of brick waste concrete 3) To compare the performance between concrete with brick waste as coarse aggregate partial replacement and conventional concrete (control concrete).

Learn More

Research Article Utilization of Recycled Concrete Aggregates

to explore waste material recycling for environmental and economic advantages. e current paper presents an experimental research on the feasibility of reusing RCA in stone mastic asphalt (SMA) mixtures as a partial replacement of coarse and ne aggregates.

Learn More

Effect of Recycling Waste Glass as Fine and Coarse Aggregate

specifications for coarse aggregate in the case of use a coarse aggregate s. 5 - Mix Concrete mixtures containing 1.5: 3 (0.5) (cement, sand, pebbles) were applied to the cement respectively. The use of partial replacement of fine sand and gravel with glass waste and ratios (5, 10) , 15, 20)

Learn More

EXPERIMENTAL STUDY ON COIR BLENDED CONCRETE STRENGTHENED

replacement of cement and using granite powder as a partial replacement of fine aggregate along with adding natural fiber (coir) to enhance the strength of the concrete and also keeping it economic by processing an alternate to the conventional. The objective of our project is to study the influence of partial replacement of cement with fly ash

Learn More

THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT WITH BONE ASH AND

Fly ash is another materials that has been used in partial replacement of cements in concrete and cement mortars, Jo et al. showed that fly ash based lightweightartificial aggregate is (2007) suitable for the production of concrete having a compressive strength of 29 N/mm 2 .

Learn More

Replacement Of Coarse Aggregate In Concrete - [Civil Planets

Using the E-waste as a partial replacement of coarse aggregate in concrete is the best solution. We can not fully replace material in concrete because it impacts the workability of concrete . The electronic waste is crushed as required particle size and can be mixed with other aggregates in concrete which will not affect the quality & durability of the concrete.

Learn More

Partial Replacement of Fine Aggregate & Coarse Aggregate by

Keywords: Concrete, waste glass powder, coconut shell, partial replacement, fine aggregate, coarse aggregate, drying shrinkage, compressive strength, workability test such slump cone test 1. INTRODUCTION Concrete is the second largest of widely used material; but there are environmental issues related with its use which are

Learn More

CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL

2.1 Introduction 4 2.2 Ceramic Waste As partial Replacement for Course Aggregate Concrete Production 4 2.2.1 Properties of Ceramic Coarse Aggregates 5 2.2.2 Properties of Concrete That Were Made from Ceramic Waste Coarse Aggregate 6 2.2.3 Type Of Ceramic Waste 9 2.2.4 Other Application of Ceramic waste substitution 9 2.3 Aggregates 10

Learn More

Literature Review on Different Waste Materials Use in Concrete

to use non biodegradable components of Electronic waste as a partial replacement of the coarse or fine aggregates. They have also studies about experimental study is made on the utilization of Electronic waste particles as coarse aggregates in concrete with a percentage replacement ranging from 0% to 30% on the strength criteria of M20 Concrete.

Learn More

Partial Replacement of Coarse Aggregate with Demolished Waste

2. Separation of the coarse aggregate from demolished waste takes time and labour. 2. LITERATURE REVIEW 1. “Use of demolished concrete waste in partial replacement of coarse aggregate in concrete” SSRG International Journal of Civil Engineering (SSRG-IJCE) – volume 3 In this paper, it is discussed that there is a large amount of

Learn More

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT OF

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT OF WASTE PLASTIC IN CONCRETE Arivalagan.S Professor and HOD INTRODUCTION Concrete is the most widely used man made construction material in the world. The primary objective of this study is to evaluate the possibility of using plastic aggregate as coarse aggregate in concrete. Specific

Learn More

Strength and Durability Properties of Granite Powder Concrete

2.1.3. Coarse Aggregate Broken granite stones were used as a coarse aggregate in concrete. Size of the coarse aggregate used in the investigation was 10 -20 mm. The specific gravity of the coarse aggregate was found to be 2.68. 2.1.4. Water Water is an important ingredient of the concrete as it actually participates in the chemical reaction

Learn More

An Analysis over Partial Replacement of Coarse Aggregate

using 0%, 5%, 10%, 15%, 20% and 25% partial replacement of waste tyre as coarse aggregate. Recycling is the most excellent choice over disposal, in this way the disposal cost is minimized and also the natural resources were conserved. The efficient way to use waste tyre is partial replacement of coarse aggregate in concrete and by

Learn More

XPERIMENTAL TUDY ON APPLICATION OF MARBLE WASTE AS

Ethiopian investment agency[15].Conventional aggregate is expensive; hence, the use of Marble waste aggregate, when it is locally available and close to the highway project it can be used as partial replacement of conventional aggregate. Use this waste makes good economic sense for project owners and contractors.

Learn More

partial replacement of fine aggregate by glass powder in concrete

Apr 05, 2015 · COARSE AGGREGATE: Coarse aggregates are particles greater than 4.75mm, but generally range between 9.5mm to 37.5mm in diameter. size of coarse aggregate:20mm GLASS POWDER: Using waste glass in the concrete construction sector is advantageous, as the production cost of concrete will go down.

Learn More

PDF Ceramic Tiles Waste As Coarse Aggregates Partial

2.1 Introduction 4 2.2 Ceramic Waste As partial Replacement for Course Aggregate Concrete Production 4 2.2.1 Properties of Ceramic Coarse Aggregates 5 2.2.2 Properties of Concrete That Were Made from Ceramic Waste Coarse Aggregate 6 2.2.3 Type Of Ceramic Waste 9 2.2.4 Other Application of Ceramic waste substitution 9 2.3 Aggregates 10

Learn More

An Analysis over Partial Replacement of Coarse Aggregate by

using 0%, 5%, 10%, 15%, 20% and 25% partial replacement of waste tyre as coarse aggregate. Recycling is the most excellent choice over disposal, in this way the disposal cost is minimized and also the natural resources were conserved. The efficient way to use waste tyre is partial replacement of coarse aggregate in concrete and by

Learn More

What are other alternatives for aggregates in concrete

1) EPS: Expanded Polystyrene plays a very unique role in concrete. Research has shown that concrete with this material behaves very similarly to light weight concretes containing traditional aggregates. This

Learn More

PDF Partial Replacement of Coarse Aggregate with Demolished

2. Separation of the coarse aggregate from demolished waste takes time and labour. 2. LITERATURE REVIEW 1. "Use of demolished concrete waste in partial replacement of coarse aggregate in concrete" SSRG International Journal of Civil Engineering (SSRG-IJCE) - volume 3 In this paper, it is discussed that there is a large amount of

Learn More

Use of Recycled Tires as Partial Replacement of Coarse

CiteSeerX - Document Details (Isaac Councill, Lee Giles, Pradeep Teregowda): It is estimated that more than 270 million scrap-tires weighing more than 3 million tons are produced in the United States each year. This waste being non-biodegradable poses severe fire, environmental and health risks. Aside from tire derived fuel, the most promising use of recycled tires is in engineering

Learn More

MECHANICAL PROPERTIES AND DURABILITY OF CONCRETE WITH

The coarse aggregate and the coarse sand used in the concrete mixes with cement replacement by ceramic powder were crushed granite aggregates. For the production of concrete samples in phase A, Portland cement, CEM I-32.5, complying with the NP EN 197-1:2001was used along with both natural sand and granite aggregates.

Learn More

PDF Experimental Study of Partial Replacement of Fine

used as partial replacement for river sand. The properties of the material investigated are presented in table 2. The size of the material used is 4.75 mm and down size. 2 Coarse aggregate: Machine crushed granite obtained from a local quarry was used as coarse aggregate. The properties of the coarse aggregate are shown in table 3

Learn More

Characteristic Studies on Concrete by Partial Replacement

Sep 10, 2019 · In present study the detailed characteristic studies of concrete is carried out by partial replacement of natural sand by waste granite powder in concrete composition with different percentages (0%, 10%, 20%, 30%, 40%, 50%).The mechanical properties of concrete like compressive strength, tensile strength are carried out by replacing the quantity of sand with waste granite powder with different percentages as mentioned above.

Learn More

PDF Characteristic Studies on Concrete by Partial Replacement

studies of concrete is carried out by partial replacement of natural sand by waste granite powder in concrete composition with different percentages (0%, 10%, 20%, 30%, 40%, 50%).The mechanical properties of concrete like compressive strength, tensile strength are carried out by replacing the quantity of sand with waste granite powder with

Learn More

Coconut Shell as Partial Replacement for Coarse Aggregate: Review

use lightweight concrete. The possibility exists for the partial replacement of coarse aggregate with coconut shell to produce lightweight concrete. Coconut shell exhibits more resistance against crushing, impact and abrasion, compared to crushed granite aggregate. Coconut shell can be grouped under lightweight aggregate.

Learn More

Utilisation of Waste Plastics as a Partial Replacement of

deals with the reuse of waste plastics as partial replacement of coarse aggregat e in M20 concrete. Usually M20 concrete is used for most constructional works. W aste Plastics were incrementally

Learn More

Experimental Study of Partial Replacement of Fine Aggregate

used as partial replacement for river sand. The properties of the material investigated are presented in table 2. The size of the material used is 4.75 mm and down size. 2 Coarse aggregate: Machine crushed granite obtained from a local quarry was used as coarse aggregate. The properties of the coarse aggregate are shown in table 3

Learn More